Project Workshop.....

Mission to Fix car damaged in an accident, owner had no insurance so we gonna help him restore his pride and glory.........

to be continued.............

September 2010 Project....Jetta VR6 3.2 LIMITED

Jetta VR6 By Sheikh Ahmed

3.2 litre
Fully modified with 278,
276 sport cams,
Perfect power management system,
Golf 4 GTI gearbox,
Silver in colour, only a few came out in this colour,
4 exhausts, very good and clean original leather seats,
Golf 5 chape headlamps,
Vr6 clean mags,
A/c, power steering,
sony MP3 player with 4 surround sound speakers,


Done by Sheikh Ahmed



Picture taken by Sheikh Ahmed



Auto Body Specialists

Car Services Repairs to all makes of cars Engine Overhauls Major and Minor Service Auto Electrical Repairs Quality Guaranteed at Affordable Price Major Services Include Safety Checks Battery Checks V belts/cambelt check New Sparkplugs,points and condenser Drive Shafts,Steering, fuel lines and cooling system Adjust hand brake and test brakes New engine oil, new oil filter New airfilter Check Lights Tune up, Labour Services we also offer: Starters and Alternators Brakes Replacements Clutch Replacements CV Joints Cambelt Replacements Gearboxes

Learn how to Rebuild a Car Battery.....

Reconditioning a Car Battery Step 1 Test the battery for charge capacity and acid ratio. Most auto parts stores will test the charge capacity of any battery for free, as they can sell you a new one if it tests bad. They place the battery on a load test machine for a few minutes (as if the car's starter were activating), and measure the results. The acid ratio tester is a small dropper filled with colored balls. Removing a cap from the top of the battery will give access to the plates and acid, where a small amount is drawn into the dropper. The float level of the various balls will indicate the acid level, which in most batteries is about one-third of the total fluid. Step 2 Drain the acid from the battery case. Proper handling equipment must be used, as the sulfuric acid is highly corrosive. The top of most lead-acid car batteries will come off with two plastic plates, covering six holes. Some smaller units will have six individual hole plugs. Each plug hole is an opening into one cell of the battery, and there are three cells in two cell banks in each 12-volt car battery. Draw this acid out completely, and use a bright light to inspect the level from the side of the battery case, if it is translucent. Step 3 Refresh the acid in the battery. Add a mix of one-third sulfuric acid to two-thirds distilled water to the battery through the six openings until it is 90 percent full. Leave a small amount of air in each cell, as hydrogen from charging can cause a buildup of pressure. Replace the caps or cap plates, then let the battery sit without a charge for about 30 minutes. Step 4 Charge the battery for 24 hours on a 1- to 5-ampere trickle charger. Do not put a load (lights, accessories, running automobiles) onto the battery until it is fully charged.

Panel Beating and Spray Painting

Car Services Repairs to all makes of cars Engine Overhauls Major and Minor Service Auto Electrical Repairs Quality Guaranteed at Affordable Price

Major Services Include Safety Checks Battery Checks V belts/cambelt check New Sparkplugs,points and condenser Drive Shafts,Steering, fuel lines and cooling system Adjust hand brake and test brakes New engine oil, new oil filter New airfilter Check Lights Tune up, Labour Services we also offer: Starters and Alternators Brakes Replacements Clutch Replacements CV Joints Cambelt Replacements Gearboxes